灌浆料在任何工程中进行施工操作的时候，都是有一些必要的注意事项，以此来保证施工，那么济南灌浆料施工安全规定有哪些呢？下面小编为您分析：

When conducting construction operations with grouting materials in any project, there are necessary precautions to ensure construction. So what are the safety regulations for grouting material construction in Jinan? The following editor will analyze for you:

1.进入施工现场的作业人员必须正确佩戴安全帽，严禁酒后上岗、施工现场严禁吸烟、严禁随地大小便。

1. Operators entering the construction site must wear safety helmets correctly, and it is strictly prohibited to work under the influence of alcohol. Smoking and urination are strictly prohibited on the construction site.

2.浇筑深基础灌浆料前和在施工过程中，应检查基坑边坡土质有无崩裂塌的危险。如发现危险现象，应立即排除。同时，工具、材料不应堆置在基坑边沿。

Before pouring the deep foundation grouting material and during the construction process, the soil quality of the foundation pit slope should be checked for any danger of collapse. If dangerous phenomena are found, they should be immediately eliminated. At the same time, tools and materials should not be stacked on the edge of the foundation pit.

3.浇筑灌浆料使用的溜槽及串筒节间应连接牢固。操作部位应有护身栏杆，不准直接站在溜槽帮上操作。

3. The chute and barrel joints used for pouring grouting materials should be firmly connected. The operating parts should have protective railings, and it is not allowed to operate directly on the chute.

4.浇筑无楼板的框架梁、柱混时，应架设临时脚手架，禁止站在梁或柱的模板或临时支撑上操作。

When pouring frame beams and column concrete without floor slabs, temporary scaffolding should be erected, and it is prohibited to operate on the formwork or temporary support of the beams or columns.

5.浇筑房屋边沿梁、柱灌浆料时，外部应有脚手架或安全网。如脚手架平桥离开建筑物超过20cm时，须将空隙部位牢固遮盖或装设安全网。

When pouring grouting materials for the edge beams and columns of the house, there should be scaffolding or safety nets outside. If the scaffolding flat bridge is more than 20cm away from the building, the gap must be securely covered or a safety net installed.

6.浇筑拱形结构时，应自两边拱脚对称地同时进行;浇圈梁、雨篷、阳台，应设防护措施;浇筑料仓时，下出料口应先行封闭，并搭设临时脚手架，以防人员下坠。

6. When pouring the arch structure, it should be carried out symmetrically from both sides of the arch foot simultaneously; Protective measures should be taken for pouring ring beams, awnings, and balconies; When pouring the silo, the lower discharge outlet should be closed first and temporary scaffolding should be erected to prevent personnel from falling.

7.夜间浇筑灌浆料，应有足够的照明设备。

7. When pouring grouting materials at night, there should be sufficient lighting equipment.

8.使用振捣器时，应按灌浆料振捣器使用安全要求执行，湿手不得接触开关，电源线不得有破损和漏电。开关箱内应装设防溅的漏电保护器，漏电保护器其额定漏电动作电流应不大于30mA，额定漏电动作时间应小于0.1s。

When using a vibrator, the safety requirements for using the grouting material vibrator should be followed. Wet hands should not touch the switch, and the power cord should not be damaged or leaked. A splash-proof leakage protector should be installed inside the switch box, with a rated leakage action current of no more than 30mA and a rated leakage action time of less than 0.1s.

9.筑作业必须设专人指挥，分工明确。

9. The construction work must be commanded by a dedicated person with a clear division of labor.

10.灌浆料振捣器使用前必须经过电工检查确认合格后方可使用，开关箱内必须装置漏电保护器，插座插头应完好无损，电源线不得破皮漏电;操作者必须穿绝缘鞋，戴绝缘手套。

10. Before using the grouting material vibrator, it must be inspected and confirmed by an electrician to be qualified before use. A leakage protector must be installed in the switch box, the socket plug should be intact, and the power cord should not be broken or leaked; Operators must wear insulated shoes and gloves.

11.在沟槽、基抗中浇注灌浆料前应检查槽帮，确认安全后方可作业。

11. Before pouring grouting material into the groove and foundation, the groove edge should be inspected and confirmed to be safe before operation.

12.沟槽深度大于3m时，应设置灌浆料溜槽，溜槽间节必须连接可靠，操作部位应设防护栏，不得直接站在溜放槽帮上操作。溜放时作业人员应协调配合。

When the depth of the groove is greater than 3m, a grouting material chute should be set up, and the joints between the chutes must be reliably connected. The operating parts should be equipped with protective barriers, and it is not allowed to directly stand on the chute side for operation. Operators should coordinate and cooperate when sliding.

13.泵送灌浆料时，宜设2名以上人员牵引布料杆。泵送管接口、安全阀、管架等必须安装牢固，输送前应试送，检修时必须卸压。

13. When pumping grouting materials, it is advisable to have at least 2 personnel pull the distribution rod. The pumping pipe interface, safety valve, pipe rack, etc. must be installed firmly, and should be tested before transportation. During maintenance, pressure must be relieved.

14.浇筑拱型结构，应自两边拱脚对称同时进行，浇筑圈梁、雨蓬、阳台应设置安全防护设施。

14. The pouring of arch structures should be carried out symmetrically and simultaneously from both sides of the arch feet. The pouring of ring beams, awnings, and balconies should be equipped with safety protection facilities.

15.浇灌2m高度以上框架柱、梁灌浆料应站在脚手架或平台上作业，不得直接站在模板或支撑上操作。浇灌人员不得直接在钢筋上踩踏、行走。

15. Grouting for frame columns and beams with a height of more than 2m should be done by standing on scaffolding or platforms, and should not be done directly on templates or supports. Pouring personnel are not allowed to step or walk directly on the steel bars.

16.向模板内灌注灌浆料时，作业人员应协调配合，灌注人员应听从振捣人员的指挥。

16. When pouring grouting material into the template, the operators should coordinate and cooperate, and the pouring personnel should follow the command of the vibrating personnel.

17.浇筑灌浆料作业时，模板仓内照明用电必须使用12V低压。

17. When pouring grouting materials, 12V low voltage must be used for lighting in the template warehouse.

18.预应力灌浆应严格按照规定压力进行，输浆管道应畅通，阀门接头应严密牢固。

18. Prestressed grouting should be strictly carried out according to the specified pressure, the slurry pipeline should be unobstructed, and the valve joints should be tight and firm.

有关对于灌浆料施工安全规定有哪些呢，暂时为大家介绍到这里，如果您对其讲述还有其他疑问或者不了解之处，可直接咨询我们工作人员，也欢迎来电//www.gochiism.com咨询探讨！

What are the safety regulations for grouting material construction? I will briefly introduce them here. If you have any other questions or are not familiar with them, you can directly consult our professional staff. You are also welcome to call us //www.gochiism.com Consultation and discussion!