It's no stranger to plastering mortar. Generally, the improved dry powder mortar is used and the dry powder material mixed with better stone well cement is used. What's the construction technology of machine spraying mortar? Let's give you a brief introduction:

粉刷砂浆产品特点：

Features of plastering mortar products:

1、现场加水搅拌即可施工，省工省料，施工方便，可明显提高施工效率，减小工作强度。

1. The construction can be carried out by adding water and mixing on site, which saves labor and materials and is convenient for construction. It can significantly improve the construction efficiency and reduce the work intensity.

2、产品质量可靠均匀，保证地面砂浆的强度，收缩低，减少收缩裂缝。

2. The product quality is reliable and uniform, ensuring the strength of the ground mortar, low shrinkage and reducing shrinkage cracks.

3、具有较高的施工性能，和易性好，施工滑爽，均匀平整。

3. It has high construction performance, good workability, smooth and even construction.

4、提高施工现场的整洁度，无需水泥、黄砂等大综原料的堆放场地，可节省大量人力。

4. Improve the cleanliness of the construction site without the storage yard of large comprehensive raw materials such as cement and yellow sand, which can save a lot of manpower.

粉刷砂浆施工工艺：

Construction process of plastering mortar:

1、面层砂浆的铺设宜在室内装饰工程基本完成后进行。

1. The laying of surface mortar should be carried out after the indoor decoration works are basically completed.

2、地面砂浆铺设时，应随铺随压实。抹平、压实工作应在砂浆凝结前完成。

2. When the ground mortar is laid, it shall be compacted at the same time. The leveling and compaction shall be completed before the mortar sets.

3、做踢脚线前，应弹好水平控制线，并应采取措施控制出墙厚度一致。踢脚线突出墙面厚度不应大于8 mm

3. Before making the skirting line, snap the horizontal control line, and take measures to control the thickness of the wall. The thickness of skirting line protruding from the wall shall not be greater than 8 mm

4、踏步面层施工时，应采取保证每级踏步尺寸均匀的措施，且误差不应大于10 mm。

4. During the construction of step surface layer, measures shall be taken to ensure the uniform size of each step, and the error shall not be greater than 10 mm.

5、地面砂浆铺设时宜设置分格缝，分隔缝间距不宜大于6 m。

5. When laying the ground mortar, the dividing joint should be set, and the spacing of the dividing joint should not be greater than 6 m.

6、地面面层砂浆凝结后，应及时养护，养护时间不应少于七天。

6. After the mortar on the ground surface is set, it shall be cured in time, and the curing time shall not be less than seven days.

7、地面砂浆施工完成后，应采取措施防止玷污和损坏。面层砂浆的抗压强度未达到设计要求前，应采取保护措施。

7. After the construction of ground mortar is completed, measures shall be taken to prevent contamination and damage. Protective measures shall be taken before the compressive strength of the surface mortar fails to meet the design requirements.

河南粘结砂浆

Henan bonded mortar

粉刷砂浆注意事项：

Precautions for plastering mortar:

1、施工前，打扫干净地面的浮灰或油污，并用水充分湿润。

1. Before construction, clean the floating ash or oil stain on the ground and fully wet it with water.

2、使用机械搅拌，加水量约为百分之十五，加水量不易过大，否则会出现表面起砂的现象。

2. Mechanical mixing is used, and the amount of water added is about 15%. The amount of water added is not easy to be too large, otherwise there will be sand on the surface.

3、施工厚度根据地面的平整度要求，厚度超过1 0 mm以上，要分层施工，需要时要留收缩缝。24h后，要浇水养护，温度较高时，还要注意铺设麻布或稻草，减少水分蒸发，造成收缩开裂。

3. The construction thickness shall be based on the flatness requirements of the ground. If the thickness exceeds 10 mm, it shall be constructed in layers, and contraction joints shall be reserved when necessary. After 24h, water for curing. When the temperature is high, pay attention to laying linen or straw to reduce water evaporation and cause shrinkage and cracking.

4、使用中遇雨雪天气应停止施工，抹灰砂浆硬化前应防止雨淋，普通型产品不能用于冬季施工；

4. In case of rain and snow during use, the construction shall be stopped. The plastering mortar shall be protected from rain before hardening. Ordinary products cannot be used for winter construction;

本文由济南抹面砂浆为您提供，我们的网站是：//www.gochiism.com我们将以全心全意的热情为您提供服务，欢迎您的访问

This article is provided by Jinan plastering mortar. Our website is: //www.gochiism.com We will provide you with services with wholehearted enthusiasm. Welcome to visit